Vertical Side Light Water Based Automotive Paint Booths
6900X3900X2650 mm ID
1. Spray booth with diesel burner heating.
2. All panels are tongue and groove interlock structure
3. Pressure device inside the control panel.
4. Quality brand-name turbo fan fans
5. Water paint system on the ceiling.
6. Spray booth specific, dual voltage LED light fixtures
7. Booths include installation instructions, fan, motor and drive,
fasteners, hardware, and sealant necessary for assembly
8. Full grilles on the floor.
In painting, outside fresh air comes into the heating generators
through the pre-filter system, and enters into the plenum, then
filtered by ceiling filter and into the both which brings clean,
symmetrical and steady-going down airflow for spraying,After
painting, the diesel burner heating with hot air circulation, until the temperature up to setting valve. Afterwards, the air with
little benzene will be released to the atmosphere after being
filtered by the air filter.
|Inside dimension||6900×3900×2650 mm (L×W×H)|
|Outside dimension||7000×5450×3400mm (L×W×H)|
|Front door||Folding door, 3 folds, 3000×2600 mm (W×H), without frame, aluminium
alloy window frame, orange colour, door head and two batten on both
sides white colour.|
|Emergency door||1 units, 800×2000mm (W×H), colour: white.|
|Basement||Galvanized steel assemble, 300mm high, quadrate steel support,
adjustable type, full grilles made by flat bar and twisted steel,
galvanized, 3 ramps, 900×2000mm/pc, silver colour.|
|Wall panel||Thickness: 50mm, width:1150mm, tongue and groove structure, 0.476mm
colour steel with rock wool inside, colour: white, bulge structure.|
|Light||Ceiling Lights: 8Units×4Pcs=32Pcs×16W, side lights:
8Units×4Pcs=32Pcs×16W, with LED, lighting boxes are powered coated,
|Generator cabinet||Intake from back upper, exhaust from rear upper, aluminum alloy
frame; orange machine-made panel covered, filled with heat
preservation material inside.|
|Intake and Exhaust system||Inlet:1×7.5KW turbo fan, air capacity for each fan: 25000m3/h.|
|Outlet: 1×7.5KW turbo fan, air capacity for each fan: 25000m3/h.
Manual damper, 5m ducts, 1 pcs 900 bend, 1 pcs 300 bend, 1 pcs intake hoop.|
|Heating system||RIELLO G20 diesel burner, double layer stainless steel heat
exchanger, pneumatic damper actuates from spraying to baking cycle.
Max. heating productivity: 200000kcal/h, max temperature: 80℃, 4pcs
chimney, 1 pcs bend.|
|Purification system||Pre-filter (pocket type), ceiling filter, fibreglass filter,
activated carbon filter (pocket type)|
|Control system||Spraying, heat spraying, baking, time setting, lighting switch,
failure indicator, thermostat, power supply switch, emergency stop,
hour meter, temperature limit controller, pressure gauge, all
motors is normal start.|
|Total power||18.5KW (Power supply 1×220V, 3×380V, 50HZ)|